混凝土攪拌車離合器摩擦片的作用就是負責把發動機的動力傳遞給傳遞齒輪，再輸出到后輪使攪拌車行駛，操作離合器片分離和結合，可以起到切斷和結合動力傳遞的作用，離合器和離合器片可以使動力更柔和，起到在發動機與車輪之間的一定的緩沖作用，使車輛平穩起步、平穩換擋和防止過載損壞發動機及傳動系統。攪拌車離合器的重要性詳細不必多說，而且攪拌車離合器如果失靈造成的事故也往往令人驚心。那么既然攪拌車離合器那么重要，那混凝土攪拌車離合器的壽命是多少呢？它又受那些因素的限制呢？或者出現什么樣的狀況需要更換？接下來技術人員為大家詳細解決。

The function of the clutch friction plate of concrete mixer is to transfer the engine power to the transmission gear, and then output it to the rear wheel to drive the truck. The clutch plate can be separated and combined to cut off and combine the power transmission. The clutch and clutch plate can make the power softer and play a certain buffer role between the engine and the wheel to make the vehicle run Smooth start, smooth shift and prevent overload damage to the engine and transmission system. The importance of the mixer clutch is needless to say in detail, and the accident caused by the failure of the mixer clutch is often alarming. So since the mixer clutch is so important, what is the service life of the concrete mixer clutch? What factors restrict it? Or what kind of condition needs to be replaced? Next, the technicians will solve the problem in detail.

影響混凝土攪拌車離合器壽命短的因素

Factors affecting short service life of concrete mixer clutch

1、攪拌車長時間踩住離合器，長時間踩著離合器不放，那么離合器一直處于工作狀態，這樣長時間的運轉非常容易造成離合器過熱，磨損過度的。

1. If the mixer holds the clutch for a long time and does not release the clutch for a long time, then the clutch is always in the working state. Such a long time of operation is very easy to cause overheating and excessive wear of the clutch.
                

2、攪拌車長時間半聯動，這個指的是在車輛的行駛過程中，一直踩著離合，踩一半，放一半，這就屬于半聯動，也叫半離合，這樣會導致分離軸承壽命嚴重縮短的，剎車片的壽命也會縮短的，也就縮短了離合器的壽命。

2. The long-time semi linkage of mixer truck refers to that during the driving process of the vehicle, the clutch is always stepped on, half stepped and half released. This belongs to semi linkage, also known as semi clutch. This will lead to serious shortening of the service life of the release bearing and the service life of the brake pad, which also shortens the service life of the clutch.

3、混凝土攪拌車起步油門過大，對于手動擋，有些人在起步的時候，喜歡猛踩油門（離合器一端是連著發動機，另一端是連著變速箱和車輪），油門過大，發動機轉速一下就上來，離合器剛剛結合的時候兩端轉速相差就很大，一頭發動機已經轉的很快，那邊才慢慢接上去速度慢。這樣擰一下對離合器會產生額外的消耗，油門超大，要么離合器打滑，要么就是輪胎打滑，對車子都是不好的。長時間這么開車是會出問題的，檔位高，速度低，從地面及變速箱傳來的阻力矩，就會特別的大。

3. The accelerator of the concrete mixer is too large. For manual transmission, some people like to step on the accelerator (one end of the clutch is connected to the engine, and the other end is connected to the gearbox and the wheel). If the accelerator is too large, the engine speed will come up immediately. When the clutch is just combined, the speed difference between the two ends will be very large. The engine at one end has been rotating very fast, and the other side is slowly It's slow to connect. This will cause extra consumption on the clutch. If the accelerator is too large, either the clutch slips or the tires slip, which is not good for the car. If you drive like this for a long time, there will be problems. The gear is high and the speed is low. The resistance torque from the ground and the gearbox will be very large.

4、攪拌車檔位越高，阻力矩就越大，阻力矩和變速箱的傳動是成反比的，變速箱的檔位越高，傳動比越小，阻力矩就越大，那連接發動機變速箱的離合器，承受的負荷也就越大，就會加速離合器片的磨損。

4. The higher the gear of the mixer truck is, the greater the resistance torque is. The resistance torque is inversely proportional to the transmission of the gearbox. The higher the gear of the gearbox is, the smaller the transmission ratio is, the greater the resistance torque is. The greater the load of the clutch connected to the engine gearbox will be, and the wear of the clutch plate will be accelerated.

混凝土攪拌車的載重比較大，對于離合器的使用要謹慎小心，希望我說的幾點能給攪拌車司機帶來幫助！

Concrete mixer truck load is relatively large, for the use of clutch to be careful, I hope I said a few points to help the truck driver!